thin-film cascadable amplifier 20 to 500 mhz technical data features ? frequency range: 20 to 500 mhz ? high output power: +23.5 dbm (typ) ? high dynamic range ? temperature compensated applications ? if/rf amplification ? mixer driver description the 546 series is a thin-film rf bipolar amplifier using lossless feedback for optimum noise figure and high dynamic range. resistive feedback and active bias compen- sate for temperature and voltage variations. internal blocking capacitors couple the rf through the amplifier. the 546 series amplifiers are available in either the to-8 hermetic case or connectored tc-1 package. uto/utc 546 series pin configuration utoto-8t rf v + in rf out utctc-1 ground case ground v + rf out rf in schematic maximum ratings parameter maximum dc voltage +17 volts continuous rf input power +13 dbm operating case temperature C55 to +100 c storage temperature C62 to +150 c r series burn-in temperature +100 c weight: (typical) uto2.1 grams; utc21.5 grams rf out rf in v+ thermal characteristics 1 q jc 55 c/w active transistor power dissipation 840 mw junction temperature above case temperature 46 c mtbf (mil-hdbk-217e, a uf @ 90 c) 366,400 hrs. www.datasheet.co.kr datasheet pdf - http://www..net/
2 electrical specifications 1 (measured in 50 w system @ +15 vdc nominal unless otherwise noted) symbol unit t c = e55 to +85 c 20-500 10.0 0.5 6.0 +22.0 2.0:1 2.0:1 ? ? ? ? mhz db db db dbm ? ? dbm dbm dbm ma t c = 0 to 50 c guaranteed specifications typical t c = 25 c 10-500 11.5 0.2 4.0 +23.5 <1.7:1 <1.8:1 +35.0 +40.0 +50.0 110 20-500 10.0 0.5 5.5 +23.0 2.0:1 2.0:1 ? ? ? ? characteristic frequency range small signal gain (min.) gain flatness (max.) noise figure (max.) power output @ +1 db comp. (min.) input vswr (max.) output vswr (max.) two tone 3rd order intercept point two tone 2nd order intercept point one tone 2nd harmonic intercept point dc current bw gp ? nf p 1db ? ? ip 3 ip 2 hp 2 i d typical performance over temperature (@ +15 vdc unless otherwise noted) key: +25 c +85 c -55 c note: 1. rf input and output connected C no blocking capacitor. 12.0 gain, db 100 gain frequency, mhz 200 11.5 11.0 300 5.0 noise figure, db frequency, mhz 4.5 4.0 3.5 noise figure 400 500 100 200 300 400 20 10.5 500 3.0 10.0
25 power output
@ 1 db gain
compression, dbm power output frequency, mhz 0 24 23 2.0 vswr input vswr frequency, mhz 1.75 1.5 1.0 vswr output vswr frequency, mhz 45 ip 3 , dbm third-order intercept point frequency, mhz 40 65 ip 2 , dbm second-order intercept point frequency, mhz 60 80 hp 2 , dbm second-harmonic intercept point frequency, mhz 70 60 50 100 200 2.0 1.75 1.5 1.25 100 200 300 1.0 100 200 400 300 55 1.25 300 400 400 100 200 300 400 100 200 500 300 22 35 50 500 500 500 400 500 0 100 200 300 400 500 30 45 0 0 40
40 35 www.datasheet.co.kr datasheet pdf - http://www..net/
3 (typical production unit @ +25 c ambient) automatic network analyzer measurements frequency vswr gain phase phase group delay vswr isolation mhz in db degrees dev ns out db numerical readings bias = 15.00 volts 100.0 1.70 10.80 153.07 e.41 .00 1.48 20.21 150.0 1.69 10.75 138.16 e.34 .83 1.56 20.25 200.0 1.72 10.75 123.16 e.39 .81 1.64 20.14 250.0 1.72 10.77 108.84 .26 .80 1.71 19.93 300.0 1.73 10.78 94.21 .60 .82 1.77 19.71 350.0 1.71 10.74 79.48 .84 .82 1.82 19.42 400.0 1.70 10.70 64.55 .88 .85 1.82 19.26 450.0 1.70 10.59 48.75 .05 .90 1.79 19.06 500.0 1.74 10.46 32.23 e1.49 .95 1.77 16.89 550.0 1.86 10.20 14.70 ? 1.00 1.72 18.76 600.0 2.10 9.81 e3.69 ? 1.05 1.63 18.85 650.0 2.51 9.26 e22.99 ? 1.09 1.52 19.01 700.0 3.15 8.43 e42.99 ? 1.09 1.38 19.51 750.0 4.09 7.38 e62.09 ? 1.07 1.19 20.14 800.0 5.46 5.99 e81.67 ? 1.05 1.12 21.13 850.0 7.35 4.30 e100.03 ? .99 1.31 22.42 900.0 9.75 2.35 e117.21 ? .95 1.62 24.04 950.0 12.78 .25 e134.39 ? .86 2.00 25.66 1000.0 16.33 e1.94 e148.23 ? .73 2.44 27.55 linearization range: 100.0 to 500.0 mhz s-parameters s 21 100.00 .261 e170.5 10.828 153.5 e19.567 154.8 .166 e174.6 200.00 .250 e167.7 10.794 124.1 e19.406 123.1 .212 160.6 300.00 .241 e161.0 10.804 95.3 e19.034 93.6 .254 125.0 400.00 .239 e148.7 10.665 65.6 e18.778 64.6 .282 82.0 500.00 .278 e132.3 10.310 34.1 e18.614 34.4 .298 32.3 600.00 .378 e122.4 9.543 e.5 e18.744 2.5 .299 e21.0 700.00 .524 e122.3 8.190 e37.8 e19.444 e31.8 .242 e73.6 800.00 .684 e129.3 5.958 e75.1 e20.911 e66.0 .086 e131.5 900.00 .811 e139.5 2.546 e110.5 e23.611 e97.7 .146 30.6 1000.00 .889 e149.2 e1.652 e142.0 e26.836 e124.7 .355 e9.0 bias = 15.00 volts frequency mhz mag ang db ang db ang mag ang s 11 s 22 s 12 www.datasheet.co.kr datasheet pdf - http://www..net/
4 product options uto e 509r screening option
blank = no screening
r = r-series screening
for more information on r-series screening,
see reliability screening, pub. 5963-3240e. model number prefix
uto-
utm-
ppa- model number utc ?509-1 connector option
for tc-1 case the only connector option
available is the -1. the -1 option consists
of a sma female connector on both the
input and output (see note). model number prefix
utc- model number note: r-series screening is not available in the tc-1 case as the case is non-hermetic. www.datasheet.co.kr datasheet pdf - http://www..net/
5 case drawings to-8t .031 .031 .50
dia .450
dia max .200 .017 0.185
0.015 +.002 - 001 .150
typ .300
typ ground case
ground v .150
typ 3 4 2 1 45 approximate weight 2.1 grams + rf in rf out glass ring
.060 dia typ
(3x) notes (unless otherwise specified): 1. dimensions are specified in inches 2. tolerances: xx .02 xxx .010 www.datasheet.co.kr datasheet pdf - http://www..net/
case drawings tc-1 gnd .350 .890 .460 .310 dc input .38
(2) pl .24 .19 sma jack (female)
(2) pl .180 .640 .905 .095 .250 .570 2-56 unc-2b x .15 deep
threaded insert
(4) pl .460 .310 .350 1.000 .820 product marking
area typical weight with connectors = 21.5 grams
rf .100 v + in rf out notes: 1. the tc-1 case is a non-hermetic case.
2. the only connector option available for the tc-1 case is the ?, sma female connectors at both input and output ports.
agc (if required) .890 .500 notes (unless otherwise specified): 1. dimensions are specified in inches 2. tolerances: xx .02 xxx .010 contact teledyne cougar: 408-522-3838 408-522-3839 fax cougaramps@cougarcorp.com check for updates: www.teledyne-cougar.com www.datasheet.co.kr datasheet pdf - http://www..net/
|
