|
If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
Datasheet File OCR Text: |
PM300CSD060 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 IntellimodTM Module Three Phase IGBT Inverter Output 300 Amperes/600 Volts A B AA - DIA. (4 TYP.) H Y AC W W W RY AC Y Z V 12 3 4 5678 9 11 13 15 17 19 T Q Q 1. V UPC 2. UFO 3. U P 4. V UPI 5. V VPC 6. VFO 7. V P 8. V VPI 9. V WPC 10. WFO TC Measured Point 11. W P 12. V WPI 13. V NC 14. V NI 15. NC 16. U N 17. V N 18. W N 19. FO P N 10 12 14 16 18 AE (15 TYP.) 63 MM AB - THD (6 TYP.) W F EC B J U V W AH AH Z G M D M S Z Z Y 2.54 MM DIA. (2 TYP.) 0.5 MM SQ. PIN (19 TYP.) AF AG X P AD U N L K Description: Powerex IntellimodTM Intelligent Power Modules are isolated base modules designed for power switching applications operating at frequencies to 20kHz. Built-in control circuits provide optimum gate drive and protection for the IGBT and free-wheel diode power devices. Features: Complete Output Power Circuit Gate Drive Circuit Protection Logic - Short Circuit - Over Current - Over Temperature - Under Voltage Low Loss Using 4th Generation IGBT Chip Applications: Inverters UPS Motion/Servo Control Power Supplies Ordering Information: Example: Select the complete part number from the table below -i.e. PM300CSD060 is a 600V, 300 Ampere IntellimodTM Intelligent Power Module. Type PM Current Rating Amperes 300 VCES Volts (x 10) 60 V WPC WP W FO V WPI OUT VCC OUT VCC OUT VCC OUT VCC OUT VCC GND GND GND GND GND GND GND GND GND GND GND GND TEMP NC N W V U OUT VCC P FO FO FO FO FO SI SI SI SI SI Outline Drawing and Circuit Diagram Dimensions A B C D E F G H J K L M N P Q R Inches 5.310.04 4.740.02 4.330.04 4.27 3.760.02 3.29 2.01 1.602 1.56 1.37 1.33 1.02 Millimeters 135.01.0 120.50.5 110.01.0 10.5 95.50.5 83.5 51.0 40.68 39.5 34.7 33.7 26.0 Dimensions S T U V W X Y Z AA AD AC AD AE AF AG AH Inches 0.69 0.65 0.52 0.43 0.39 0.30 0.285 0.24 0.22 Dia. Metric M5 0.128 0.10 0.08 0.07 0.06 0.02 Millimeters 17.5 16.5 13.2 11.0 10.0 7.7 7.25 6.0 Dia. 5.5 M5 3.22 2.6 2.0 1.8 1.6 0.5 0.95 +0.06/-0.0 24.1 +1.5/-0.0 0.85 0.79 0.780 21.5 20.0 19.82 SI FO IN IN IN IN IN IN V UPC UP U FO V UPI V VPC VP V FO V VPI V NC WN FO NC VNI VN UN 1 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM300CSD060 IntellimodTM Module Three Phase IGBT Inverter Output 300 Amperes/600 Volts Absolute Maximum Ratings, Tj = 25C unless otherwise specified Characteristics Power Device Junction Temperature Storage Temperature Case Operating Temperature Mounting Torque, M5 Mounting Screws Mounting Torque, M5 Main Terminal Screws Module Weight (Typical) Supply Voltage Protected by OC and SC (VD = 13.5 - 16.5V, Inverter Part) Tj = 125C Isolation Voltage, AC 1 minute, 60Hz Sinusoidal Symbol Tj Tstg TC -- -- -- VCC(prot.) VISO PM300CSD060 -20 to 150 -40 to 125 -20 to 100 31 31 920 400 2500 Units C C C in-lb in-lb Grams Volts Volts IGBT Inverter Sector Collector-Emitter Voltage (VD = 15V, VCIN = 15V) Collector Current, (TC = 25C) Peak Collector Current, (TC = 25C) Supply Voltage (Applied between P - N) Supply Voltage, Surge (Applied between P - N) Collector Dissipation (TC = 25C) VCES IC ICP VCC VCC(surge) PC 600 300 600 400 500 781 Volts Amperes Amperes Volts Volts Watts Control Sector Supply Voltage Applied between (VUP1-VUPC, VVP1-VVPC, VWP1-VWPC, VN1-VNC) Input Voltage Applied between (UP-VUPC, VP-VVPC, WP-VWPC, UN- VN- WN-VNC) Fault Output Supply Voltage (Applied between FO and VC) Fault Output Current (UFO, VFO, WFO, FO) VD VCIN VFO IFO 20 20 20 20 Volts Volts Volts mA Electrical and Mechanical Characteristics, Tj = 25C unless otherwise specified Characteristics Symbol Test Conditions Min. Typ. Max. Units IGBT Inverter Sector Collector Cutoff Current ICES VCE = VCES, Tj = 25C, VD = 15V, VCIN = 15V VCE = VCES, Tj = 125C, VD = 15V, VCIN = 15V Diode Forward Voltage Collector-Emitter Saturation Voltage VEC VCE(sat) -IC = 300A, VD = 15V, VCIN = 15V VD = 15V, VCIN = 0V, IC = 300A, Tj = 25C VD = 15V, VCIN = 0V, IC = 300A, Tj = 125C Inductive Load Switching Times ton trr tC(on) toff tC(off) VD = 15V, VCIN = 0 ~ 15V VCC = 300V, IC = 300A Tj = 125C 0.4 -- -- -- -- 0.8 0.15 0.4 2.0 0.6 2.0 0.3 1.0 2.9 1.2 S S S S S -- 1.7 2.3 Volts -- -- 2.2 1.7 3.3 2.3 Volts Volts -- -- 10 mA -- -- 1.0 mA 2 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM300CSD060 IntellimodTM Module Three Phase IGBT Inverter Output 300 Amperes/600 Volts Electrical and Mechanical Characteristics, Tj = 25C unless otherwise specified Characteristics Symbol Test Conditions Min. Typ. Max. Units Control Sector Over Current Trip Level Inverter Part (VD = 15V) Short Circuit Trip Level Inverter Part Over Current Delay Time Over Temperature Protection (VD = 15V) Supply Circuit Under Voltage Protection (-20 Tj 125C) Circuit Current SC toff(OC) OT OTR UV UVR ID VCIN(on) VCIN(off) IFO(H) IFO(L) Minimum Fault Output Pulse Width* tFO OC Tj = -20C Tj = 25C Tj = 125C -20C Tj 125C, VD = 15V VD = 15V Trip Level Reset Level Trip Level Reset Level VD = 15V, VCIN = 15V, VN1-VNC VD = 15V, VCIN = 15V, VXP1-VXPC Input ON Threshold Voltage Input OFF Threshold Voltage Fault Output Current* Applied between UP, VP, WP, UN, VN, WN VD = 15V, VFO = 15V VD = 15V, VFO = 15V VD = 15V -- 651 390 -- -- 111 -- 11.5 -- -- -- 1.2 1.7 -- -- 1.0 -- 766 -- 760 10 118 100 12.0 12.5 45 15 1.5 2.0 -- 10 1.8 1270 1060 -- -- -- 125 -- 12.5 -- 62 20 1.8 2.3 0.01 15 -- Amperes Amperes Amperes Amperes S C C Volts Volts mA mA Volts Volts mA mA mS *Fault output is given only when the internal OC, SC, OT and UV protections schemes of either upper or lower devide operate to protect it. Thermal Characteristics Characteristic Junction to Case Thermal Resistance Symbol Rth(j-c)Q Rth(j-c)F Rth(j-c)Q Rth(j-c)F Contact Thermal Resistance Rth(c-f) Condition Each IGBT Each FWDi Each IGBT** Each FWDi** Case to Fin Per Module, Thermal Grease Applied ** TC measured point is just under chip. If you use this value, Rth(f-a) should be measured just under the chips. Min. -- -- -- -- -- Typ. -- -- -- -- -- Max. 0.16 0.24 0.10 0.16 0.018 Units C/Watt C/Watt C/Watt C/Watt C/Watt Recommended Conditions for Use Characteristic Supply Voltage Control Supply Voltage*** Symbol VCC VD VCIN(on) VCIN(off) fPWM tDEAD Condition Applied across P-N Terminals Applied between VUP1-VUPC, VN1-VNC, VVP1-VVPC, VWP1-VWPC Input ON Voltage Input OFF Voltage PWM Input Frequency Minimum Dead Time Applied between UP, VP, WP, UN, VN, WN Using Application Circuit Input Signal 0 ~ 0.8 4.0 ~ VD 0 ~ 20 2.5 Volts Volts kHz S Value 0 ~ 400 15 1.5 Units Volts Volts *** With ripple satisfying the following conditions: dv/dt swing 5V/s, Variation 2V peak to peak. 3 Powerex, Inc., 200 Hillis Street, Youngwood, Pennsylvania 15697-1800 (724) 925-7272 PM300CSD060 IntellimodTM Module Three Phase IGBT Inverter Output 300 Amperes/600 Volts SATURATION VOLTAGE CHARACTERISTICS (TYPICAL) (INVERTER PART) DIODE FORWARD CHARACTERISTICS (INVERTER PART) REVERSE RECOVERY CURRENT VS. COLLECTOR CURRENT (TYPICAL) 2.0 DIODE FORWARD CURRENT, -IF, (AMPERES) SATURATION VOLTAGE, VCE(sat), (VOLTS) 103 REVERSE RECOVERY TIME, trr, (S) 100 VD = 15V Tj = 25oC Tj = 125oC VCC = 300V VD = 15V Tj = 25oC Tj = 125oC INDUCTIVE LOAD 103 REVERSE RECOVERY CURRENT, Irr, (AMPERES) 1.5 VD = 15V VCIN = 0V Tj = 25oC Tj = 125oC 102 1.0 10-1 102 101 0.5 0 0 50 100 150 200 250 300 COLLECTOR CURRENT, IC, (AMPERES) 100 0 0.5 1.0 1.5 2.0 2.5 DIODE FORWARD VOLTAGE, VFM, (VOLTS) 10-2 101 102 COLLECTOR CURRENT, IC, (AMPERES) 101 103 SWITCHING LOSS CHARACTERISTICS TRANSIENT IMPEDANCE, Zth(j-c), (NORMALIZED VALUE) TRANSIENT THERMAL IMPEDANCE CHARACTERISTICS (IGBT) TRANSIENT THERMAL IMPEDANCE CHARACTERISTICS (FWDi) TRANSIENT IMPEDANCE, Zth(j-c), (NORMALIZED VALUE) 102 CONDITIONS: HALF-BRIDGE INDUCTIVE LOAD SWITCHING OPERATION Tj = 25oC Esw(off) Tj = 125oC Esw(on) VCC = 300V VGE = 15V 101 101 SWITCHING LOSS, ESW (mJ/PULSE) 100 100 101 10-1 10-1 100 10-2 STANDARD VALUE Rth(j-c)Q = 0.16oC/W SINGLE PULSE 10-2 STANDARD VALUE Rth(j-c)Q = 0.24oC/W SINGLE PULSE 10-1 101 102 COLLECTOR CURRENT, IC, (AMPERES) 103 10-3 10-3 10-2 10-1 TIME, (s) 100 101 10-3 10-3 10-2 10-1 TIME, (s) 100 101 4 |
Price & Availability of PM300CSD060 |
|
|
All Rights Reserved © IC-ON-LINE 2003 - 2022 |
[Add Bookmark] [Contact Us] [Link exchange] [Privacy policy] |
Mirror Sites : [www.datasheet.hk]
[www.maxim4u.com] [www.ic-on-line.cn]
[www.ic-on-line.com] [www.ic-on-line.net]
[www.alldatasheet.com.cn]
[www.gdcy.com]
[www.gdcy.net] |